Birty Dastards Jeep Club

Please login or register.

Login with username, password and session length
Advanced search  
Pages: [1]   Go Down

Author Topic: orange coolant light  (Read 10459 times)

0 Members and 1 Guest are viewing this topic.

pafc11

  • Guest
orange coolant light
« on: May 05, 2009, 07:57:24 PM »
recently had a new radiator fitted and since then the dash orange coolant warning light is on permanent, now the only sensor i think it could be is the one that pops into the plastic water tank/ is there a quick fix?

Tempted just to put a bit of black tape over light and just keep checking levels are good  :wink:
Logged

Mike Pavelin

  • Guest
Re: orange coolant light
« Reply #1 on: May 05, 2009, 07:59:42 PM »
Check the sensor in the coolant header tank. If it is ok, but there is evidence of coolant being forced out of the pressure cap, you need to investigate further as you may have a cracked cylinder head.
Logged

pafc11

  • Guest
Re: orange coolant light
« Reply #2 on: May 05, 2009, 08:08:41 PM »
should have added. jeep running fine, been doing few good runs with it and all seems ok, just the constant light is a bit annoying, lights been on for months now, and  thought while im here im just aswell ask.

few weeks ago was wierd tho.. engine running sweet all day, next morning started her up.

engine was banging and knocking all over the place, this is 6.30 am.. wakes all the neighbours up 8-)

neighbours dread me going to work tho for some reason :lol:
Logged

Bishops Finger

  • Guest
Re: orange coolant light
« Reply #3 on: May 05, 2009, 11:26:56 PM »
One of the many delights of a 2.5 engine.... :twisted:
Logged

Dave69

  • Club Member
  • Guru
  • *
  • Guru: 15
  • Offline Offline
  • Posts: 9457
  • Vehicle: CJ-7 4.2 auto
  • Year: 1979
Re: orange coolant light
« Reply #4 on: May 07, 2009, 08:36:19 PM »
reason for pushrod jumping out is a lazy hydraulic lifter, run an engine flush and change the oil to new and it shoul solve the problem.
 when i had mine a just welded some nuts to the rocker arms to stop this.

got it down to 10 mins to pop one back in after it jumped out. hence the added nuts
Logged
XJ 2.5 diesel - dead. XJ 4.0 6" lift - sold to some lucky person
CJ7 4.2 auto standard(ish)
Alfa 147 jtdm

wildrover

  • Guest
Re: orange coolant light
« Reply #5 on: June 22, 2009, 11:06:19 AM »
Quote from: pafc11 on May 05, 2009, 07:57:24 PM
recently had a new radiator fitted and since then the dash orange coolant warning light is on permanent, now the only sensor i think it could be is the one that pops into the plastic water tank/ is there a quick fix?

I had the same problem on my 2.5 diesal....i got rid of the annoying orange light by removing the sensor from the water bottle , then putting a small bit of wire into the connector to complete the circuit and cause the light to go out...This is only a temporary measure till i get a new sensor , and of course i check the water level much more often , and keep an eye on the tempreture , as now i don,t have any warning of low coolant level....
Logged

paulh

  • Guest
Re: orange coolant light
« Reply #6 on: June 24, 2009, 10:16:51 PM »
Ah thats the ones i like to hear, just gone out and done that :icon_wink: ta very much.
Logged
Pages: [1]   Go Up
« previous next »
 
Powered by EzPortal