Birty Dastards Jeep Club

Please login or register.

Login with username, password and session length
Advanced search  
Pages: [1]   Go Down

Author Topic: will a later front axle shaft fit a 1995 xj with ABS  (Read 4095 times)

0 Members and 1 Guest are viewing this topic.

skyusdi

  • Guest
will a later front axle shaft fit a 1995 xj with ABS
« on: May 29, 2017, 11:32:04 AM »
Hi everyone

I have tried searching but cannot seem to find an definite answer.  Will a axle shaft say from a 1997 xj fit my 1995 xj or will any other model fit aswell?  I have removed my drivers side one to replace the U joint, but noticed that the ABS tone ring is looking a bit worse for wear, it still works but looking at getting another shaft to replace it and passenger side if it goes through MOT. Then keep originals as spares.

The axle I have is Dana M30/181MM Front Axle.

The Date the Jeep was first Registered 27 September 1995

Thanks in advance for any help.
Logged

carljh

  • Guru
  • *
  • Guru: 0
  • Offline Offline
  • Posts: 167
Re: will a later front axle shaft fit a 1995 xj with ABS
« Reply #1 on: May 29, 2017, 02:22:59 PM »
Logged

skyusdi

  • Guest
Re: will a later front axle shaft fit a 1995 xj with ABS
« Reply #2 on: May 29, 2017, 03:33:52 PM »
That's the piece, thanks.  Just wondering about the full shafts, so could get a spare set.

Thanks again
Logged

The Smiths

  • Guru
  • *
  • Guru: 1
  • Offline Offline
  • Posts: 1084
Re: will a later front axle shaft fit a 1995 xj with ABS
« Reply #3 on: May 29, 2017, 04:24:24 PM »
They will - you can also just change the tone ring
Logged
If you always do what you have always done You will always get what you have always got
Please give to our Mac4x4 fund: http://www.justgiving.com/The-Smiths-2015

skyusdi

  • Guest
Re: will a later front axle shaft fit a 1995 xj with ABS
« Reply #4 on: May 29, 2017, 04:45:33 PM »
Thanks for the info. Just looked up the tone ring,not to bad on price  I take it they come off with heat and a puller and go back on with heat, to expand then allowed to cool?
Logged

The Smiths

  • Guru
  • *
  • Guru: 1
  • Offline Offline
  • Posts: 1084
Re: will a later front axle shaft fit a 1995 xj with ABS
« Reply #5 on: May 29, 2017, 04:53:02 PM »
If the old one is buggered then just use a chisel to get them off - I have done this on ones and they have come off OK.

As for refitting heating is a good idea - but the interference fit is not that severe really
Logged
If you always do what you have always done You will always get what you have always got
Please give to our Mac4x4 fund: http://www.justgiving.com/The-Smiths-2015

Brynjaminjones

  • "Abe Lincoln"
  • Club Member
  • Guru
  • *
  • Guru: 8
  • Offline Offline
  • Posts: 2444
  • Vehicle: '98 XJ Cherokee 4.0 Limited, '97 ZJ Grand Cherokee 4.0 Limited, '91 Hunter Green SJ Grand Wagoneer 360
Re: will a later front axle shaft fit a 1995 xj with ABS
« Reply #6 on: May 29, 2017, 05:51:17 PM »
 :iagree: I'm useless, and even I managed to replace my rusty ones with nothing but a hammer and screwdriver  :003:
Logged

JamesH

  • Club Member
  • Guru
  • *
  • Guru: 1
  • Offline Offline
  • Posts: 4998
  • Vehicle: JK
  • Year: 2010
Re: will a later front axle shaft fit a 1995 xj with ABS
« Reply #7 on: May 30, 2017, 01:08:29 PM »
Just be careful with the hammer because the tone rings are quite brittle if you are clumsy with a lump hammer  :icon_redface:

Logged

skyusdi

  • Guest
Re: will a later front axle shaft fit a 1995 xj with ABS
« Reply #8 on: June 02, 2017, 10:10:02 PM »
Well finally got the axle back in and everything bolted up.  Had fun removing the U joints, not sure but think they were the originals, the Jeep was not looked after before I had it.  I had to use a Grinder and cut the Cross out of the joints.  Then the caps would not move with the proper tool, so ended up the old fashioned way of Hammer and Vise. Now going to look at getting some spare shafts and fit some new tone rings.

Thanks for all the info.  It has been a great help.
Logged
Pages: [1]   Go Up
« previous next »
 
Powered by EzPortal